瑞士Sensirion ASL1600-10熱非侵入性低流量流量計，40至1000微升/分鐘

瑞士Sensirion ASL1600-10熱非侵入性低流量流量計，40至1000微升/分鐘

納米和微流測量精密實驗室應用

分辨率可達500 PL/分鐘

響應時間<50毫秒

這些液體質量流量計使超低液體質量流量快速和精確的測量，并與總的介質隔離，很少死體積，以及沒有運動部件進行操作。該流量計檢測到液體的質量流量，通過測量通過玻璃毛細管的管材料的熱傳遞。在毛細管外的微芯片上的熱優化膜的加熱電阻器被保持高于環境溫度。在毛細管內液體流動的情況下，溫度分布的上游和下游被干擾，這種差異進行測量。 CMOSens?sensor技術結合使用的數字信號處理在一個CMOS芯片高精度的熱傳感器元件。此外，CMOSens傳感器技術的數字智能與pc機、PLC等控制器的連接的數字化接口。

所有的測量數據完全校準，并通過內部微控制器來進行溫度補償。優良的耐化學性和生物相容性得到保障，并且處理介質只獲取與所述直傳感器的毛細管接觸。典型應用該傳感器包括精確液體的質量流量和體積測量為分析儀器，醫療器械，和過程控制。型號32611-00至-08校準的只有水。測量信號的優良的重復性仍維持為其他媒體，因而允許計算機或微控制器上后測量校正。模型32611-10被校準為IPA，但也可以用于其它烴類，如乙醇，丙酮，柴油，石油，醚和大多數其他媒體的可重復的測量結果，但是它不與水溶液工作。

包含的內容：

型號32611-00到-04：PC軟件，2微米在線過濾器，OD360PEEK?毛細血管，RS-232數據線，AC適配器，用于110至230 VDC。型號32611-06和-08：PC軟件，UNF10-32裝修，RS-232數據線，AC適配器，用于110至230 VDC。型號32611-10：尾纜，接頭1/8''OD塑料管材、倒刺和镥聯接器。

Thermal Non-Invasive Low-Flow Flowmeters, 40 to 1000 μL/min

Nano-and micro-flow measurements for precision laboratory applications

Resolutions down to 500 pL/min

Response time < 50 ms

These liquid mass flowmeters enable extremely fast and accurate measurements of ultra-low liquid mass flows, and operate with total media isolation, very little dead volume, and no moving parts. The flowmeter detects liquid mass flow by measuring heat transfer through the tubing material of a glass capillary. On a microchip outside the capillary, a heating resistor on a thermally optimized membrane is kept above ambient temperature. In the presence of liquid flow inside the capillary, the temperature distribution upstream and downstream is disturbed—this difference is then measured. CMOSens^?sensor technology combines a high-precision thermal sensor element with digital signal processing on one single CMOS chip. In addition, the digital intelligence of the CMOSens sensor technology enables digital interfaces that permit an easy link with PCs, PLC, and other controllers.

All measurement data is fully calibrated and temperature compensated by means of an internal microcontroller. Excellent chemical resistance and bio-compatibility are ensured, and the process medium only gets in contact with the straight sensor capillary. Typical applications for this sensor include precise liquid mass flow and volume measurement for analytical instruments, medical devices, and process control. . Models 32611-00 to -08 are calibrated for water only. Superior repeatability of the measurement signal is still maintained for other media and thus allows after-measurement-correction on a computer or microcontroller. Model 32611-10 is calibrated for IPA only but can also be used for repeatable measurements of other hydrocarbons such as ethanol, acetone, diesel, petroleum, ether, and most other media; however it does not work with aqueous solutions.

What's Included:
Models 32611-00 to -04: PC software, 2 μm in-line filters, OD360 PEEK^? capillaries, RS-232 data cable, AC adapter for 110 to 230 VDC. Models 32611-06 and -08: PC software, UNF 10-32 fitting, RS-232 data cable, AC adapter for 110 to 230 VDC. Model 32611-10: pigtail cable, fittings for 1/8’’ OD plastic tubing, and barb and luer connectors.